Symptoms
Engine revs rise without the vehicle speeding up, especially on hills or when towing. Burning smell.
Likely cause
A worn clutch plate, oil on the friction surface from a leaking rear main or gearbox seal, or incorrect adjustment.
Suggested fixes
Listed roughly in the order most owners try them.
- 1
Check clutch adjustment
On Series vehicles check there is free play at the pedal. A clutch with no free play will slip.
- Difficulty:
- Easy DIY
- Cost:
- £ (Under about £50 in parts)
- 2
Replace the clutch
Fit a new plate, cover and release bearing together. Fix any oil leaks before fitting, or the new clutch will slip too.
- Difficulty:
- Experienced DIY
- Cost:
- ££ (About £50 to £300)
This is general guidance gathered from owner experience and workshop practice, not a substitute for a workshop manual or a qualified mechanic. Costs are rough parts-only guides. Brakes, steering and suspension work affects safety, so if in doubt have it checked professionally.
Related faults
- Gearbox & transferHigh severity
Clutch pedal goes to the floor
Pedal sinks or stays down, clutch drags so gears are hard to select, fluid loss from the reservoir.
Series I · Series II / IIA · Series III · 90 / 110 / 127 · Defender3 fixes - Gearbox & transferHigh severity
Clutch release fork pivot failure on LT77 and R380
Sudden loss of clutch with no hydraulic fault, the clutch pedal still has pressure but nothing happens.
90 / 110 / 127 · Defender · 200Tdi, 300Tdi, Td52 fixes - Gearbox & transferHigh severity
Clutch will not disengage on Series (cross-shaft failure)
Clutch pedal works but the vehicle will not come out of gear, or the pedal suddenly goes light with no clutch action.
Series II / IIA · Series III3 fixes - Gearbox & transferMedium severity
LT230 transfer box whine or rumble
A whine or rumble from under the seats that changes with road speed, sometimes louder in low range.
90 / 110 / 127 · Defender2 fixes